<noframes id="htvzn">

歡迎您訪問萊州聚峰機械有限公司網站!
攪拌機行業持續先行者!
點擊撥打服務熱線:400-879-1999
您的位置: 首頁 > 新聞資訊>>什么原因導致攪拌機存在抱軸問題

新聞資訊

熱銷產品

推薦新聞

  • 安全使用規范是什么?
  • 聚峰混凝土攪拌車,您的選擇!
  • 高效作業的前提:即正確使用混凝土攪拌車
  • 聚峰帶你了解混凝土攪拌車的價格
  • 聚峰淺談自上料攪拌車
  • 中科聚峰廠家告訴你如何使用小型混凝土攪拌機

全國服務熱線

400-879-1999
新聞資訊 /news

什么原因導致攪拌機存在抱軸問題

來源:http://www.dinghelaw.com/ 日期:2022-11-23
概述:什么原因導致攪拌機存在抱軸問題呢?小型攪拌機廠家認為可能是原料投料位置問題。攪拌混凝土所用的物料主要是砂石骨料、水泥、粉煤灰、水和
什么原因導致攪拌機存在抱軸問題呢?小型攪拌機廠家認為可能是原料投料位置問題。攪拌混凝土所用的物料主要是砂石骨料、水泥、粉煤灰、水和外加劑等。原料水泥若包裹砂石遇水結塊,如果攪拌不充分就容易粘在攪拌軸上,若水泥進料口位置方向不合理,使攪拌軸不能快速充分攪拌,就容易形成抱軸現象。
What causes the shaft holding problem of the mixer? The manufacturer of small mixer thinks that it may be the problem of raw material feeding position. The materials used for mixing concrete are mainly sand aggregate, cement, fly ash, water and additives. If the raw cement is wrapped with sand and gravel and agglomerates in water, it is easy to stick to the mixing shaft if the mixing is not sufficient. If the position and direction of the cement feed inlet are unreasonable, the mixing shaft cannot be quickly and fully mixed, and it is easy to form the phenomenon of shaft holding.
或者是攪拌主機進水管與沖水位置原因。沖水點位置和沖洗方向不正確的話,又或者是沖水壓力過低,導致水在進入主機內部后,不能講暫時粘結在軸上的混凝土沖洗掉,則時間久了就容易形成抱軸。
Or the water inlet pipe and flushing position of the mixing host. If the position and direction of the flushing point are incorrect, or the flushing pressure is too low, so that the concrete temporarily bonded to the shaft cannot be washed off after the water enters the main engine, it is easy to form a shaft holding after a long time.
也可以生產之后沒有及時對攪拌機內部進行清洗,或清洗不干凈,導致攪拌軸表面仍有殘留的混凝土,干燥后凝固在攪拌軸上,如果長期如此則非常容易產生抱軸現象。
It is also possible that after production, the internal part of the mixer is not cleaned in time, or the cleaning is not clean, which leads to the residual concrete on the surface of the mixing shaft, which solidifies on the mixing shaft after drying. If this is done for a long time, it is very easy to produce the phenomenon of holding the shaft.
只有進行基本的維護,我們的工作才能正常進行,如?。?/div>
Only by carrying out basic maintenance can our work be carried out normally, such as:
小型攪拌機
1,如遇雷雨或惡劣天氣,小型混凝土攪拌機的吊桿不能使用。吊桿不得在風力大于8級的天氣下使用;操作小型混凝土攪拌機吊桿時,所有吊桿應在操作人員的視線范圍內。
1. In case of thunderstorm or bad weather, the suspender of small concrete mixer cannot be used. The suspender shall not be used in weather with wind force greater than 8; When operating the suspenders of small concrete mixers, all suspenders shall be within the sight of the operator.
2,啟動小型混凝土攪拌機時的危險區域是末端軟管擺動的周圍區域。面積直徑是末端軟管長度的兩倍。端部軟管長度大于3m時,危險區域直徑為6m;小型混凝土攪拌機端部軟管不得彎曲,端部軟管不得放入混凝土中。
2. The dangerous area when starting the small concrete mixer is the area around the end hose swinging. The area diameter is twice the length of the end hose. When the length of the end hose is more than 3m, the diameter of the hazardous area is 6m; The end hose of small concrete mixer shall not be bent, and the end hose shall not be put into the concrete.
3,作為備用支架,以標準方式操作動臂,并注意動臂與導線之間的距離。
3. As a backup support, operate the boom in a standard way and pay attention to the distance between the boom and the wire.
這就要求我們在操作攪拌機前后準備好相關的材料和定期進行其維修檢查,還能在一定程度上延長他的使用壽命。更多關于相關內容就來我們網站http://www.dinghelaw.com咨詢看看吧!
This requires us to prepare relevant materials and conduct regular maintenance and inspection before and after operating the mixer, which can also extend its service life to a certain extent. Come to our website for more information http://www.dinghelaw.com Consult!

截屏,微信識別二維碼

エロどうじん同人し誌アニメ